Product ID:1204 PRIME COAT INSULATING COMPOUND PART A
MSDS Date:07/20/1987
FSC:5970
NIIN:01-225-5548
MSDS Number: BHCLH

DOW CORNING CORP

3901 SOUTH SAGINAW ROAD
MIDLAND, MI 48640
US

Emergency Phone: 517-496-5900

Info Phone: 517-496-5900

Preparer: JACK L. SHENEBERGER

Cage: 5D028

ROBERT MCKEOWN CO.(201-218-9000)

AUBURN, MI 48611 US

Telephone: 517-496-4388

Cage: 7B984

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

OSHA PEL 100 PPM

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

N-BUTYL ALCOHOL (SARA III)

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 100 PPM

ACGIH TLV: S, C 50 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-METHOXYETHYLORTHOSILICATE

OSHA PEL 5PPM/METHYLCELLOSOLV

ACGIH TLV: 25PPM/METHYLCELLOSOL

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:IRRITATION,CORNEAL INJURY.
SKIN:SHORT EXPOSURE,NO ADVERSE EFFECT.REPEATED OR PROLONGED
EXPOSURE CAUSE IRRITATION. INHALATION:IRRITATION OF NOSE AND
THROAT.VAPORS MAY INJURE BLOOD,LUNGS,LIVER,KIDN EYS,AND NERVOUS
SYSTEM. INGESTION:NO EFFECT FROM SMALL AMOUNTS.LARGE AMOUNTS MAY
CAUSE SLIGHT INJURY.
Explanation of Carcinogenicity:METHYLCELLOSOLVE MAY FORM UPON
HYDROLYSIS.THIS CHEMICAL HAVE CAUSED ANIMAL BIRTH DEFECTS.
Effects of Overexposure:EYES:IRRITATION. SKIN:IRRITATION AFTER REPEATED
OR PROLONGED EXPOSURE. INHALATION:DROWSINESS,IRRITATION OF NOSE AND
THROAT.
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF AILMENTS
OR WITH A PRE-EXISTING DISEASE INVOLVING THE EYES, SKIN, OR
RESPIRATORY TRACT MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION:REMOVE TO FRESH AIR. RESUSCITATE IF NOT BREATHING.
GET MEDICAL ATTENTION. EYES:IMMEDIATELY FLUSH WITH PLENTY OF WATER
FOR 15 MINUTES HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
SKIN:REMOVE CONTAMINATED CLOTHING. WASH WITH SOAP AND WATER. IF
IRRITATION PERSISTS, GET MEDICAL ADVICE. INGESTION:DO NOT INDUCE
VOMITING. GIVE NOTHING BY MOUTH IF UNCONSCIOUS. GET IMMEDIATE
MEDICAL ATTENTION.

Flash Point Method:CC
Flash Point:=15.C, 59.F
Lower Limits:1
Upper Limits:7
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD USE NIOSH APPROVED SCBA &
FULL PROTECTIVE EQUIPMENT WHEN FIGHTING CHEMICAL FIRE. USE WATER
SPRAY TO COOL NEARBY CONTAINERS EXPOSED TO FIRE.
Unusual Fire/Explosion Hazard:VAPORS HEAVIER THAN AIR.CAN TRAVEL A LONG
DISTANCE ALONG GROUND AND FLASHBACK.

Spill Release Procedures:REMOVE IGNITION SOURCES.VENTILATE.WEAR PROPER
PROTECTIVE EQUIPMENT.ABSORB IN INERT ABSORBENT AND PLACE IN
APPROPIATE DISPOSAL CONTAINER AND COVER.FLUSH RESIDUE WITH LARGE
AMOUNTS OF WATER.
Neutralizing Agent:NOT APPLICABLE.

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
AREA. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. KEEP AWAY
FROM IGNITION SOURCES AND INCOMPATIBLE MATERIALS
Other Precautions:STATIC ELECTRICITY MAY ACCUMULATE AND CREATE A FIRE
HAZARD.GROUND FIXED EQUIPMENT.BOND AND GROUND TRANSFER CONTAINERS
AND EQUIPMENT.

Respiratory Protection:IF VENTILATION DOES NOT MAINTAIN INHALATION
EXPOSURES BELOW PEL(TLV), USE NIOSH/MSHA APPROVED ORGANIC VAPOR
CARTRIDGE AND DUST/MIST PRE-FILTER RESPIRATORS AS PER CURRENT 29
CFR 1910.134, INSTRUCTIONS/ WARNINGS AND NIOSH-RESPIRATOR
SELECTION.
Ventilation:MECHANICAL (GENERAL) ROOM VENTILATION AND LOCAL EXHAUST ARE
RECOMMENDED.
Protective Gloves:NEOPRENE, NITRILE, PVC OR NATURAL RUBBER
Eye Protection:SAFETY GOGGLES WITH OPTIONAL FACE SHIELD
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED/REPEATED EXPOSURE.DO NOT GET ON SKIN/EYES.DO NOT
BREATHE VAPORS/MISTS.-INHALING LIQUID WHILE VOMITING CAN INJURE
LUNGS SERIOUSLY.IF VOMIT OCCURS,KEEP HEAD LOWER THAN HIPS TO
PREVENT AS PIRATION.-THIS IS PART A OF A 2-PART PRODUCT,FOR PART
B,SEE PNI B,SAME NSN.-KEY1:J1.

HCC:F2
Boiling Pt:=98.9C, 210.F
B.P. Text:210F,99C
Vapor Pres:25
Vapor Density:3.8
Spec Gravity:0.77
Evaporation Rate & Reference:<1 (ETHER=1)
Appearance and Odor:LIQUID.LIGHT STRAW COLOR.SOLVENT ODOR.
Percent Volatiles by Volume:95

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, WATER OR MOISTURE.
Stability Condition to Avoid:EXPOSURE TO AIR, HIGH TEMPERATURES,
SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:METAL OXIDES, SILICON DIOXIDE, CARBON
MONOXIDE, CARBON DIOXIDE, TRACES OF INCOMPLETELY BURNED CARBON
PRODUCTS.

Waste Disposal Methods:ADVISE YOUR LOCAL ENVIRONMENTAL OFFICER.DISPOSAL
SHOULD BE MADE IN ACCORDANCE WITH ALL APPLICABLE FEDERAL, STATE AND
LOCAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.